header |
|
|
|
#1
12-04-2012, 09:07 AM
|
||||
|
||||
|
Motor/Tranny exposed, what now?
I pulled the rear seat back off my 02 X30 so I can get it reskinned in the off season. I went ahead and pulled the middle insert and I was wondering if you guys had any advice on stuff I should do "while I'm in here" as I don't imagine I'll be pulling the seatback off again once I get the skin back on. I was going to do the transmission fluid anyway as part of my yearly maintenance. Any suggestions. Thanks.
|
|
#3
12-04-2012, 12:21 PM
|
|||
|
|||
|
lubricate moving parts such as tranny shift linkages, clean air filter, clean the fiberglass under the seat...
__________________
1993 Blue Stars and Stripes Prostar Powerslot 351HO Mastercraft: Face It - If you are not a good skier behind this boat, you are not a good skier.
|
|
#4
12-04-2012, 05:31 PM
|
||||
|
||||
|
Russlars is right. I change my fuel filter every year. Some might think it's overkill - beats swapping a few beers for a tow and wasting 1/2 a day for a repair.
|
|
#5
12-04-2012, 06:04 PM
|
||||
|
||||
|
Good time for some deep cleaning/painting of the engine compartment/bilge.
If you have more than 200hrs on the fuel pump and are going to replace the filter, then you may as well for under $100 just replace the fuel pump while you have the module pulled. Fuel pumps are notorius for only lasting 3-400hrs max on our boats. Trans fluid, yes. Trans filter if that hasn't been done in the last 1-200hrs. Grease as mayo said. Double check all the wiring/connections. Clean any connections to ground.
__________________
'06 X2 MCX "I understand why some people may not want to do this the way I have recommended but I can't understand the death grip some people have on a toilet plunger with a hose fitting." -JimN
|
|
#6
12-04-2012, 09:59 PM
|
||||
|
||||
|
I'm glad I don't have to work on that engine lol. I like my DD -- everything right there in plain view with lots of room to work.
Carefully inspect any rubber hoses, and replace as necessary. If they're original they are ten years old now.
__________________
1984 Stars and Stripes Powerslot White with blue stripes.
|
|
#8
12-05-2012, 01:33 PM
|
||||
|
||||
|
Quote:
__________________
'06 X2 MCX "I understand why some people may not want to do this the way I have recommended but I can't understand the death grip some people have on a toilet plunger with a hose fitting." -JimN
|
|
#9
12-05-2012, 01:41 PM
|
||||
|
||||
|
Duct tape still unopened in the pic though.
__________________
- Peter TIRE & WHEEL SALES email:tiresplease@gmail.com WEEKEND WHEEL SPECIAL Two 14" Aluminum wheels $195 Two 15" Aluminum wheels $215 Four 14" Aluminum wheels $370 Free Freight within lower 48  Steel and galvanized wheels available.
|
|
#10
12-05-2012, 01:48 PM
|
||||
|
||||
|
Jafo9 - Forget about re-skinning the seats. Just stretch duct tape over all the storage pods. You can even spice it up with fancy colors for that extra special look. Strad, I hear ya... I just switched from DD and I am not a fan of engine access on the new X2.
|
 |
| Thread Tools | |
| Display Modes | |
|
|
1999 Prostar 205 with 330 HP LTR
Hybrid Mode
