TeamTalk

TeamTalk (http://www.mastercraft.com/teamtalk/index.php)
-   General Discussion (http://www.mastercraft.com/teamtalk/forumdisplay.php?f=6)
-   -   HELP, pink milk in hull (http://www.mastercraft.com/teamtalk/showthread.php?t=56145)

Quick 07-21-2013 07:27 PM

HELP, pink milk in hull
 
I have a 1991 PS 190 and today when I was coming off the lake I went to pull the plug and noticed transmission fluid mixed with water in the bottom of the engine compartment. It is a 1.52:1 trans and the only thing I have done lately was change the packing. I have put maybe 1.5 hrs on it since then and it was dripping well before I covered it up. Is there a seal or something on the trans that might have let loose or is it time for a rebuild?

Thanks

etduc 07-21-2013 08:51 PM

Quote:

Originally Posted by Quick (Post 959087)
I have a 1991 PS 190 and today when I was coming off the lake I went to pull the plug and noticed transmission fluid mixed with water in the bottom of the engine compartment. It is a 1.52:1 trans and the only thing I have done lately was change the packing. I have put maybe 1.5 hrs on it since then and it was dripping well before I covered it up. Is there a seal or something on the trans that might have let loose or is it time for a rebuild?

Thanks

Could be a front or rear trans. seal. A leaking hose/fitting. I had one, that leaked right where the fitting is attached to the hose, at the trans cooler. Dry/Clean out your bilge, put newspaper, paper towels under trans, and wait.

Your boat is over 20 years old, a rebuild is not out of the question. I just did mine, about a month ago. It's not that hard.

FrankSchwab 07-22-2013 01:45 AM

Figure out where the leak is, and proceed from there. Wash down the trans with some soapy water and a brush (not a pressure washer), rinse it off, drain the bilge and let everything dry. Put some newspaper in the bilge under the transmission ( or a white sheet, or some paper towels), drop the boat in the water, run it for two minutes and see where the ATF is dripping. It might be a hose going to the cooler, it might be a front or rear seal. Once you know, the fix will be a lot more obvious.

Quick 07-22-2013 06:36 AM

Thank you, I will do that in the next few days and see what I can determine.


All times are GMT -4. The time now is 06:31 AM.