TeamTalk

TeamTalk (http://www.mastercraft.com/teamtalk/index.php)
-   Electrical (http://www.mastercraft.com/teamtalk/forumdisplay.php?f=23)
-   -   Location of fuel sending unit on 93 maristar 225 (http://www.mastercraft.com/teamtalk/showthread.php?t=54075)

john jones 05-04-2013 11:10 PM

Location of fuel sending unit on 93 maristar 225
 
My fuel sending unit it stuck on 3/4 of a tank. I think its time to replace. I am wondering where it is located and how to get to it. I have a 93 Maristar 225 direct drive.

Thanks

mikeg205 05-04-2013 11:40 PM

Quote:

Originally Posted by john jones (Post 932230)
My fuel sending unit it stuck on 3/4 of a tank. I think its time to replace. I am wondering where it is located and how to get to it. I have a 93 Maristar 225 direct drive.

Thanks

Isn't the tank just forward of the v-drive?

Table Rocker 05-05-2013 12:01 AM

Quote:

Originally Posted by mikeg205 (Post 932237)
Isn't the tank just forward of the v-drive?

Not on a 93 Maristar 225 direct drive.:)

mikeg205 05-05-2013 12:03 AM

1 Attachment(s)
Quote:

Originally Posted by Table Rocker (Post 932245)
Not on a 93 Maristar 225 direct drive.:)

doh!!! I meant aft .. of the trans...lol ;)

Table Rocker 05-05-2013 12:16 AM

Quote:

Originally Posted by mikeg205 (Post 932246)
doh!!! I meant aft .. of the trans...lol ;)

On top of the gas tank is all I know. :confused:

supreme112279 05-05-2013 12:22 AM

its on the top on the gas tank

john jones 05-05-2013 12:34 AM

I assume its under the rear seat, not quite sure how to get the rear seat back off? Anyone ever taken one of these apart?

f925 05-05-2013 01:30 AM

Should be similar to my 90 maristar 240. If you flip up the sun pad behind the back bench you should have a round plastic access hatch. Twist to remove and you should see the top of the sending unit/ fuel pickup.


Sent from my iPhone using Tapatalk

TN Barefooter 05-05-2013 07:22 AM

NOt certain about the Maristar sending units put on my PS 190 the magnets had come undone on the the unit. The tank always read 1/4 tank. All we did was reattach the magnets and the sending unit wokrs great.

JimN 05-05-2013 08:49 AM

Quote:

Originally Posted by john jones (Post 932258)
I assume its under the rear seat, not quite sure how to get the rear seat back off? Anyone ever taken one of these apart?

If you look at the fiberglass across the back, it should have a center section that's separate from the sides. Open the rear cover and remove all of the cushions, put a light in the rear storage area and use a mirror to look for stainless nuts on bolts. This section will have to be loosened, so it can be moved out of the way to gain access to the sender, which is on the top of the tank, under the center section. It's not that hard to get at- I think it has 4 bolts and three screws (along the bottom edge, at the floor.

If you remove the sender and are able to repair it, start by placing a small strip of tape on the sender's flange AND the tank, then cut the tape where it transitions from one to the other, so the sender can be removed without disturbing the other piece of tape. If you replace the sender, make sure the holes in the sender match the tank.

This is important because the holes aren't evenly spaced and if the sender is rotated, the screws won't go in straight and the gasket won't seal properly.


All times are GMT -4. The time now is 07:28 PM.